hostel gas steam fire tube boiler manufacturers

Gas furnace gas and steam steam steam importance gas gas gas steam hostel steam fire tube boiler manufacturers steam importance furnace gas and steam must sample tests, measuring visual quality of heat transfer fluids, flash point, viscosity, acid, water, and carbon residue, and certificate of quality manufacturing plant to provide heat transfer fluids are consistent, but also provide the basis for future changes in the operation of medium quality monitoring. Means passing the tests of the gas-steam heat transfer fluids using pumps to transfer fluids within the furnace and the injection of hot expander. When pumps heat transfer fluid to the injection system, should check again the furnace, heating equipment, piping system drain valve, drain valve is closed, in order to avoid loss of heat transfer fluids. While the exhaust pipe and the valve opening on the furnace one by one, to exclude air, until a closed gas steam flows. It stops when the oil level gauge appears on the expander injection heat transfer fluids, and then start the circulation pump, for circulating cold.

Hefei is the blue sky to win the Battle of key areas for innovation to create an international influence is of great significance. Is determined to win the battle of the blue sky, the city combined with the actual situation, formulate a three-year action plan to win the embodiment Battle of blue sky. Details are as follows.

I. Target: 2020, sulfur dioxide, total nitrogen oxide emissions were reduced over 23.1% in 2015, more than 24.2%; PM2.5 concentration decreased more than 18% in 2015, the ratio of the number of days air quality assessment requirements up to the national , severe pollution and over several days ratio decreased by more than 25% compared with 2015; the full realization of "thirteen five" binding targets.

Second, the continued implementation of the total coal consumption control. By 2020, the city's coal accounts for a further decline in the proportion of total energy consumption; the city's total coal consumption to complete the tasks assigned by the national and provincial; new coal projects to implement the reduction of coal instead.

The development of special programs, shutting down vigorously eliminate environmental protection, energy consumption, safety and other 300,000 kilowatts coal-fired units of non-compliance. For shutting down the unit's capacity, coal consumption and emissions targets, allowed to trade or replacement may be within the total national and provincial construction plan developed according to the control range, co-ordinate arrangements for the construction of ultra-low emission coal-fired capacity unit.

Third, the implementation of the "coal to gas" and "electricity instead of coal." Under the premise of the implementation of the gas source, protect people's livelihood, ceramic, glass, foundry industry to actively promote natural gas instead of coal gasification project, orderly implementation of coal-fired facilities from coal to gas. Combined with regional and industry characteristics can actively promote industrial production, building heating and cooling, transportation, agricultural production, the implementation of the residents living in five major areas "electricity instead of coal", focus on improving the proportion of final energy consumption of electricity accounted for. Of the new "coal to gas" projects, we should adhere to increase coal gas reduction to gas will change under the premise signed gas supply contracts, orderly implementation.

Fourth, to carry out comprehensive improvement of coal-fired boilers, coal-fired boilers to increase efforts to eliminate, consolidate the results of coal-fired boilers eliminated. Coal-fired boiler (with tea furnace, operating a stove, grain storage and drying equipment, coal-fired facilities) carried out an intensive investigation, one by one registration. The city basically eliminated 35 tons of steam per hour of coal-fired boilers and furnaces tea, operating the stove, grain storage and drying equipment, coal-fired facilities, no new 35 tons of steam per hour of coal-fired boilers; 35 tons of steam per hour and coal-fired boiler above (except boilers fired power plant) all meet special requirements emission limits; allowed to remain 65 tons of steam per hour coal-fired boiler and above all the complete energy transformation and ultra-low emissions within the city. County (city) district, zone one by one before the end of June 2019 to develop low-nitrogen combustion rehabilitation programs for existing gas boiler, complete combustion of low nitrogen transformation in this area of ​​existing gas boiler before the end of 2019 more than 50%, before the end of 2020 transformation is substantially complete; after transformation principle NOx emission is not higher than 50 mg / m, and comply with appropriate safety boiler specification. Urban built-up area of ​​ultra-low emission biomass boilers implement reform.

A heated hostel steam fire tube boiler manufacturers is called a boiler. Heat transfer oil, also known as organic heat carrier or heat medium oil, has been used as intermediate heat transfer medium in industrial heat transfer for more than 50 years. Based on the idea of forced cycle design, a once-through boiler is developed. Generally, coal, oil and steam are used as fuel, heat conduction oil is used as the medium, hot oil circulation pump is used to force the medium into liquid phase circulation, heat energy is transmitted to the heating equipment and then returned to the heating furnace for re-heating. High operating temperature at low pressure, and high precision control for medium operation. The heat utilization rate of the system is high, and the transportation and maintenance are convenient. The closed circulation heat supply is connected with the atmosphere, can extend the service life of the boiler, liquid phase or gas phase transportation heating. The boiler adopts three-way coil design, the system sets the expansion water tank, and realizes low-pressure and high-temperature heating. The coil structure is adopted, the heating surface is sufficient, and the expansion is fully absorbed. Imported low-NOX combustion machine, combustion charge, belongs to environmental protection products. Boiler can choose advanced touch screen computer controller and digital computer controller automatic control system. With automatic temperature regulation, automatic ignition, and differential pressure, overtemperature, quenching protection. Boiler manufacturing standards, strictly in accordance with the relevant national standards. Pot The use of furnace water quality requirements: some users believe that as long as the boiler to maintain water can be, the water quality is not a choice. In fact, the quality of water on the boiler or have an impact, the editor recommends that you choose clean tap water. Because if there are impurities in the water, the use of this impurity water will have some impact on the equipment. The impurities form a thick layer of scale on the inner wall of the boiler. Scale will gradually thicken with time, and the accumulation of thickness will affect its heat transfer efficiency, resulting in a waste of energy consumption. If the scale appears, it should be cleaned up in time, so that the heat can be concentrated in the scale, which is not easy to emit. .

There are build on the control of emissions of nitrogen oxides hostel steam fire tube boiler manufacturers in order to achieve NOx emissions from combustion boilers of less than 30mg / m3, reached the world advanced level. Austrian far low nitrogen fuel gas boiler Staged Combustion Process of the invention into three regions in the furnace combustion techniques, primary combustion zone into the small portion of the fuel, the fuel required for the combustion air into the furnace in stages, the air volume of 80% left and right into the main combustion zone, the primary combustion zone of the upper (downstream of the flame) of the fuel injected into the secondary combustion and the formation of Carrying out a reducing atmosphere in the third zone into the combustion air required Further, complete burnout process. To create a discharge for the control of nitrogen oxides boiler fuel and air in order to achieve staged combustion gas boilers achieve emission limits is very basic configuration of environmental protection facilities, comprising an electrostatic precipitator or bag filter, gas boiler efficient desulfurization apparatus, a selective catalytic reduction (SCR) or selective non-catalytic reduction (SNCR) and the like denitration apparatus. All aspects of air pollution sources to install automatic monitoring facilities, steam boilers and networking with the environmental protection department, install a distributed control system (DCS system), real-time monitoring of gas boiler pollutant emissions. All-premixed combustion technology implementation of a number of Austrian far improved combustion technology after years of build have on the control of emissions of nitrogen oxides boiler fuel and air in order to achieve staged combustion. This technique can be gas boiler NOx emissions chain by 70% -60%. At present, to solve pollution problems of small and medium industrial gas boilers have four energy saving way. First, clean fuels covered by the remaining gas boilers, boiler premix combustion technology implementation of a number of improved combustion technology after years of Austrian far as natural gas boilers, biomass boilers and so on; Second, the rising water boiler technology.